叉车蓄电池品牌众多如何选择？

合力叉车电池关键点2：日常检查
1、外观：蓄电池表面肮脏将引起漏电，应使蓄电池表面随时清洁、干燥。
2、接线柱、导线、盖子：必须经常检查蓄电池接线柱接合处、与导线的连接处因氧化引起的腐蚀情况，同时检查盖子是否变形、是否有发热现象。
3、液面：低于额定的液面，将缩短蓄电池的使用寿命，而且电解液太少将导致蓄电池发热损坏，因此，必须经常注意电解液是否足够。

合力叉车电池关键点3：保管
1、保管场所：不能使之短路；因雨淋导致短路可能产生火灾，并可能产生少量氢气，因此必须将蓄电池存放在通风、阴凉的场所。
2、废旧的蓄电池：废旧的蓄电池仍然存有电能，应按照使用的蓄电池存放方法进行保管。
合力叉车电池关键点4：寿命终期蓄电池的操作
1、寿命终期蓄电池的操作：蓄电池接近寿命终期时，单格电池内的电解液消减得非常快，应每天补充蒸馏水。
2、废旧蓄电池的处理：对于废旧蓄电池，抽出电解液，将蓄电池分解。可商谈是否由蓄电池生产厂家回收。
合力叉车电池关键点5：电解液的操作
1、检查比重：使用吸入式比重计检查比重，作业时不要让电解液溅洒出来，并要穿戴保护用具。
2、除检查以外的操作：应向*人员咨询，特别是补充电解液（稀硫酸）时。
3、电解液泄露：由于蓄电池倾翻、破损导致电解液泄露，应立即进行紧急处理（参照紧急处理事项）
合力叉车电池关键点6：紧急处理
1、电解液溅洒到眼睛：用大量清水冲洗，然后接受*医生的治疗
2、电解液溅洒到衣服：立即脱下衣服，用水冲洗后再用弱碱性皂液冲洗。
3、电解液溅到皮肤上：用大量水冲洗
4、电解液泄露：电解液泄露到外部时，立即用石灰、强碳酸苏打或碳酸苏打等进行中和，并用大量的水冲洗。
Industrial and commercial enterprises with high frequency of daily use forklift, battery directly affects the efficiency and life of the forklift, how to choose a good forklift battery? There are a lot of forklift battery manufacturers currently on the market, but because of the scale of R & D strength is different, so the battery is also different, so choose forklift battery must choose some domestic well-known brand with good reputation. In the purchase of forklift batteries to prevent adverse manufacturers to brand-name products with fish brand logo, so buy time to look at, not only is the logo, the warranty card production date and serial number of the product is complete, and the best Jiangsu manufacturers to check, prevent being cheated. Pay attention to power matching, according to the different purpose of the forklift is usually to choose the appropriate battery. In particular, we should pay attention not to choose a small power battery used in high-power forklift, will lead to the occurrence of safety accidents, serious waste batteries. At the time of purchase to stay in mind, especially to the brand of customer service, customer service is only good to you after the failures and problems solved very well.
Industrial and commercial enterprises with high frequency of daily use forklift, battery directly affects the efficiency and life of the forklift, how to choose a good forklift battery? There are a lot of forklift battery manufacturers currently on the market, but because of the scale of R & D strength is different, so the battery is also different, so choose forklift battery must choose some domestic well-known brand with good reputation. In the purchase of forklift batteries to prevent adverse manufacturers to brand-name products with fish brand logo, so buy time to look at, not only is the logo, the warranty card production date and serial number of the product is complete, and the best Jiangsu manufacturers to check, prevent being cheated. Pay attention to power matching, according to the different purpose of the forklift is usually to choose the appropriate battery. In particular, we should pay attention not to choose a small power battery used in high-power forklift, will lead to the occurrence of safety accidents, serious waste batteries. At the time of purchase to stay in mind, especially to the brand of customer service, customer service is only good to you after the failures and problems solved very well.
Six key points of using forklift battery
Heli forklift battery key point 1: maintenance
1, charging: battery charging process will produce gas, should maintain a good ventilation place, there is no open flame around the same time, the oxygen generated during the charging process, acidic gas will have an impact on the surrounding. During charging, the charging plug unplug the charger will produce arc, closed, can pull the plug. After charging a lot of hydrogen around the storage battery, do not allow any open flame, should open the battery cover to charge.
2, add water: in accordance with the provisions of the liquid level to add distilled water, do not add water in order to extend the interval and add too much distilled water, water will overflow excessive electrolyte leakage.
3, terminal, wire, cover maintenance: must be designated by the manufacturer of professional and technical personnel can be carried out.
4, clean: if it is not too dirty, can use wet cloth to wipe clean, if very dirty, it will be necessary to remove the battery from the car, water after cleaning to dry naturally.
Heli forklift battery key 2: daily check
1, appearance: battery surface dirty will cause leakage, should make the battery surface clean, dry.
2, terminal, wire, cover: must always check the battery terminal connection, and the connection of the wire due to oxidation caused by corrosion, at the same time check whether the deformation of the lid, whether there is a fever.
3, liquid level: below the rated liquid level, will shorten the service life of the battery, and the electrolyte will lead to battery heat damage, therefore, must always pay attention to the electrolyte is enough.
Heli forklift battery key point 3: custody
1, place: short circuit cannot be reduced; because the rain may cause a short circuit fire, and may have a small amount of hydrogen, so the battery must be stored in a cool, ventilated place.
2, the old battery: waste battery still has power, should be stored in accordance with the use of storage methods.
Heli forklift battery key point 4: the operation of battery life
1, end of life of the battery: battery operation close to the end of life, the electrolyte cell within the cut very quickly, should be added to distilled water every day.
2, the disposal of waste batteries: for the old battery, extract the electrolyte, the battery decomposition. Can be discussed by the battery manufacturer recycling.
Heli forklift battery key point 5: electrolyte operation
1, check the proportion: the use of inhaled hydrometer to check the specific gravity of the work, do not let the electrolyte splash out, and to wear protective equipment.
2, in addition to the operation of the inspection: should consult the professional, especially when the electrolyte (dilute sulfuric acid).
3, electrolyte leakage: due to battery turnover, damage caused by electrolyte leakage, should be immediately emergency treatment (refer to emergency treatment)
Heli forklift battery key point 6: emergency treatment
1, electrolyte splashed into the eyes: rinse with plenty of water, and then accept the treatment of professional doctors
2, the electrolyte spattered clothes: immediately took off his clothes, washing and alkalescent soap rinse.
3, electrolyte splashed on the skin: flush with plenty of water
4, electrolyte leakage: electrolyte leakage to the outside, immediately with lime, soda or soda ash and so on, and with a lot of water flushing